基体偏压对高功率脉冲磁控溅射制备CrAlN薄膜性能的影响

张辉,巩春志,王晓波,张炜鑫,田修波

中国表面工程 ›› 2022, Vol. 35 ›› Issue (5) : 200-209.

PDF(10271 KB)
PDF(10271 KB)
中国表面工程 ›› 2022, Vol. 35 ›› Issue (5) : 200-209. DOI: 10.11933/j.issn.1007-9289.20210623001

基体偏压对高功率脉冲磁控溅射制备CrAlN薄膜性能的影响

  • 张辉,巩春志,王晓波,张炜鑫,田修波
作者信息 +

Effect of Substrate Bias on the Properties of Craln Films Prepared by High Power Pulsed Magnetron Sputtering

  • ZHANG Hui, GONG Chunzhi, WANG Xiaobo, ZHANG Weixin, TIAN Xiubo
Author information +
文章历史 +

摘要

为了防止氢扩散导致金属材料的失效,通常在其表面制备一层 CrN 阻氢薄膜。但是 CrN 涂层的热稳定性较差,抗氧化温度低于 600 ℃。采用高功率脉冲磁控溅射技术,利用 Cr 和 Al 双靶共沉积 CrAlN 薄膜来提高其高温抗氧化性能。试验变量为基体负偏压的大小,分别为-100 V、-200 V、-300 V 和-400 V。结果表明,四组 CrAlN 薄膜均为柱状晶结构,随着基体偏压提高,膜层的致密度提高,但同时薄膜沉积速率下降;CrAlN 薄膜的择优生长方向为 Cr(200)晶面法线方向。四组 CrAlN 薄膜的氢抑制率均超过 70%,氢原子扩散系数最低比 316L 不锈钢基体低 3 个数量级。当基体偏压为-300 V 时,可以同时获得最优的氢抑制率(87.4%)和最低的氢原子扩散系数(6.188×10?10 cm2 / s)。600 ℃、氧气气氛下保温 60 min,CrAlN 膜基结合面处氧含量仅为表面处的 30%左右。相比于 CrN 薄膜,在相同基体偏压下,CrAlN 薄膜的氢原子扩散系数更小;高偏压下制备的 CrAlN 薄膜氧增重量仅为 316L 不锈钢基体的 10%,抗氧化性能更好。

Abstract

In order to prevent the failure of metal materials caused by hydrogen diffusion, a layer of CrN hydrogen barrier film is usually prepared on its surface. However, the thermal stability of CrN thin film is poor, and the oxidation resistance temperature is lower than 600 ℃. CrAlN thin films are co deposited by high power pulsed magnetron sputtering with Cr and Al targets to improve high temperature oxidation resistance. The experimental variable is the negative bias voltage of the matrix, which is -100 V, -200 V, -300 V and -400 V respectively. The results show that the four groups of CrAlN films are columnar crystal structure. With the increase of substrate bias voltage, the density of the films increases, but the deposition rate decreases; The preferred growth direction of CrAlN film is the normal direction of Cr(200) crystal plane. The hydrogen inhibition rate of the four groups of CrAlN films is more than 70%, and the diffusion factor of hydrogen atom is three orders of magnitude lower than that of 316L stainless steel. When the substrate bias is -300 V, the optimal hydrogen inhibition rate (87.4%) and the lowest hydrogen diffusion factor (6.188×10?10 cm2 / s) can be obtained simultaneously. The oxygen content at the interface of CrAlN film substrate is only about 30% of that at the surface when it is kept at 600 ℃ for 60 min in oxygen atmosphere. Compared with CrN films, the hydrogen diffusion factor of CrAlN films is smaller under the same substrate bias; The weight gain of oxygen of CrAlN films prepared at high bias voltage is only 10% of that of 316L stainless steel substrate, and its oxidation resistance is better.

关键词

CrAlN;高功率脉冲磁控溅射;基体偏压;阻氢;高温抗氧化

Key words

CrAlN; high power pulsed magnetron sputtering; substrate bias; hydrogen resistance; high temperature oxidation resistance

引用本文

导出引用
张辉,巩春志,王晓波,张炜鑫,田修波. 基体偏压对高功率脉冲磁控溅射制备CrAlN薄膜性能的影响[J]. 中国表面工程, 2022, 35(5): 200-209 https://doi.org/10.11933/j.issn.1007-9289.20210623001
ZHANG Hui, GONG Chunzhi, WANG Xiaobo, ZHANG Weixin, TIAN Xiubo. Effect of Substrate Bias on the Properties of Craln Films Prepared by High Power Pulsed Magnetron Sputtering[J]. China Surface Engineering, 2022, 35(5): 200-209 https://doi.org/10.11933/j.issn.1007-9289.20210623001

参考文献

[1] 凌文,刘玮,李育磊,等.中国氢能基础设施产业发展战略研究[J].中国工程科学,2019,21(3):76-83.LING Wen,LIU Wei,LI Yulei,et al.Research on thedevelopment strategy of China's hydrogen energyinfrastructure industry[J].China Engineering Science,2019,21(3):76-83.(in Chinese)
[2] 董健.铁铝合金/氧化锆/磷酸盐复合阻氢涂层制备及其性能研究[D].北京:北京科技大学,2020.DONG jian.Preparation and properties of Fe Al alloy/zirconia/phosphate composite hydrogen barriercoating[D].Beijing:Beijing University of Science andTechnology,2020.(in Chinese)
[3] 周池楼,何默涵,肖舒,等.不锈钢表面阻氢涂层研究进展[J].化工进展,2020,39(9):3458-3468.ZHOU Chilou,HE Mohan,XIAO Shu,et al.Researchprogress of hydrogen barrier coatings on stainless steel [J].Progress in Chemical Industry,2020,39(9):3458-3468.(in Chinese)
[4] 王玫,牛栋华,胡琪,等.二维材料调控阻氢涂层研究进展[J].化工学报,2017,68(S1):9-17.WANG Mei,NIU Donghua,HU Qi,et al.Researchprogress of hydrogen barrier coating controlled bytwo-dimensional materials[J].Journal of ChemicalEngineering,2017,68(S1):9-17.(in Chinese)
[5] GOLUBEVA A V,Cherkez D I.Hydrogen retention intungsten alloys developed for fusion facilities[J].Physicsof Atomic Nuclei,2019,82(7):996-1004.
[6] LI W Z,CHEN Q Z,POLCAR T,et al.Influence of Zralloying on the mechanical properties,thermal stabilityand oxidation resistance of Cr-Al-N coatings[J].AppliedSurface Science,2014,317:269-277.
[7] 夏虎峰,田广科,陈庆春,等.不同工作环境下CrN涂层的摩擦磨损性能[J].中国表面工程,2019,32(6):56-62.XIA Hufeng,TIAN Guangke,CHEN Qingchun,et al.Friction and wear properties of CrN coating underdifferent working conditions[J].China SurfaceEngineering,2019,32(6):56-62.(in Chinese)
[8] WANG D Y,WENG K W.Deposition of CrN coatings bycurrent-modulating cathodic arc evaporation[J].Surface &Coatings Technology,2001,137(1):31-37.
[9] HOFMANN S,JEHN H A.Oxidation behavior of CrNxand(Cr,Al)Nx hard coatings[J].Materials and Corrosion,1990,41(12):756-760.
[10] 宋肖肖,李柯,赵婕宇,等.磁控溅射 Cr/CrN 和Cr/CrN/CrAlN 涂层的抗高温氧化性能[J].中国表面工程,2020,33(1):63-72.SONG Xiaoxiao,LI Ke,ZHAO Jieyu,et al.Hightemperature oxidation resistance of magnetron sputteredCr/Crn and Cr/Crn/Craln coatings[J].China SurfaceEngineering,2020,33(1):63-72.(in Chinese)
[11] OHTA R,GERILE N,KAGA M,et al.Composite Si-Ninanoparticles produced by plasma spraying physical vapordeposition for negative electrode in Li-ion batteries.[J].Nanotechnology,2021.
[12] NAKAHARA R,SAKAI M,KIMURA T,et al.Lasingaction of ZnO nanowires grown by mist chemical vapordeposition using thin Au layer on-plane sapphiresubstrate[J].Japanese Journal of Applied Physics,2021,60(5):62-73.
[13] 张新宇.直流、射频磁控溅射制备Al2O3薄膜工艺探索及其性能的研究[D].太原:中北大学,2017.ZHANG Xinyu.Process exploration and performancestudy of Al2O3 thin films prepared by DC and RFmagnetron sputtering[D].Taiyuan:North University ofChina,2017.(in Chinese)
[14] MASAHIRO G,MICHIKO S,XU Yibin,et al.Controlof p-type and n-type thermoelectric properties of bismuthtelluride thin films by combinatorial sputter coatingtechnology[J].Applied Surface Science,2017,407:405-411.
[15] 金浩,张莹莹,时卓,等.磁控溅射技术制备CrAlN涂层的研究进展[J].材料导报,2016,30(3):54-59.JIN Hao,ZHANG Yingying,SHI Zhuo,et al.Researchprogress of CrAlN coating prepared by magnetronsputtering[J].Material Guide,2016,30(3):54-59.(inChinese)
[16] LI Yang,YANG Li,XIA Hong,et al.Influence of surfacemodification of carbon fiber based on magnetronsputtering technology on mechanical properties of carbonfiber composites[J].Materials Research Express,2020,7(10):105602-.
[17] VLADIMIR K,KAROL M,JOCHEN M,et al.A novelpulsed magnetron sputter technique utilizing very hightarget power densities[J].Surface & Coatings Technology,1999,122(2):290-293.
[18] 张玉琛,张海宝,陈强.高功率脉冲磁控溅射制备ZnO薄膜的研究进展[J].真空,2021,58(1):72-77.ZHANG Yuchen,ZHANG Haibao,CHEN Qiang.Research progress of ZnO thin films prepared by highpower pulsed magnetron sputtering[J].Vacuum,2021,58(1):72-77.(in Chinese)
[19] PARK S H,CHANG J H,MINEGISHI T,et al.Investigation on the ZnO:N films grown on(0001)and(0001ˉ)ZnO templates by plasma-assisted molecularbeam epitaxy[J].Joumal of Crystal Growth,2009,311(7):2167-2171.
[20] 付英英,李红轩,吉利,等.CrN 和CrAlN薄膜的微观结构及在不同介质中的摩擦学性能[J].中国表面工程,2012,25(6):34-41.FU Yingying,LI Hongxuan,JI L,et al.Microstructure andtribological properties of CrN and CrAlN films indifferent media[J].China Surface Engineering,2012,25(6):34-41.(in Chinese)
[21] 郭玉垚,王铁钢,李柏松,等.高功率脉冲和脉冲直流磁控共溅射CrAlN薄膜的研究[J].表面技术,2019,48(4):137-144.GUO Yuyao,WANG Tiegang,LI Baisong,et al.Study onCrAlN thin films co sputtered by high power pulsed andpulsed DC magnetron[J].Surface Technology,2019,48(4):137-144.(in Chinese)
[22] 王宇星,张侠.基体偏压对磁控溅射制备CrAlN纳米多层薄膜微观结构和力学性能的影响[J].机械工程材料,2021,45(3):41-45.WANG Yuxing,ZHANG Xia.Effect of substrate bias onMicrostructure and mechanical properties of CrAlN nanomultilayer films prepared by magnetron sputtering[J].Mechanical Engineering Materials,2021,45(3):41-45.(inChinese)
[23] LIU Jia,MA Cuiying,DU Huiling.A Comparative studyof TiAlN and CrAlN coatings deposited on sialon ceramiccutting inserts by physical vapor deposition[C]//Scienceand Engineering Research Center.Proceedings of 20172nd International Conference on Applied Mechanics,Electronics and Mechatronics Engineering(AMEME2017).DEStech Publications,2017:316-324.
[24] 刘孟奇,郭惠霞,王永欣,等.CrN/CrAlSiN 涂层海水环境下的摩擦学性能[J].中国表面工程,2017,30(2):63-70.LIU Mengqi,GUO Huixia,WANG Yongxin,et al.Tribological properties of CrN/CrAlSiN coating inseawater[J].China Surface Engineering,2017,30(2):63-70.(in Chinese)
[25] 朱宇杰,马景灵,王广欣,等.HIPIMS 技术制备CrN及 CrAlN 涂层的性能[J].材料热处理学报 2019,40(4):127-135.ZHU Yujie,MA Jingling,WANG Guangxin,et al.Properties of CrN and CrAlN coatings prepared by hipimstechnology[J].Journal of Material Heat Treatment,2019,40(4):127-135.(in Chinese)
[26] LIN Jianliang,WILLIAM D S,JOHN J M,et al.High ratedeposition of thick CrN and Cr2N coatings usingmodulated pulse power(MPP)magnetron sputtering[J].Surface & Coatings Technology,2010,205(10):3226-3234.
[27] 吕艳红,孔庆花,吉利,等.氮气流量对中频非平衡反应磁控溅射制备CrAlN薄膜性能的影响[J].中国表面工程,2011,24(4):7-12.LüYanhong,KONG Qinghua,JI Li,et al.Effect ofnitrogen flow rate on properties of CrAlN thin filmsprepared by medium frequency unbalanced reactivemagnetron sputtering[J].China Surface Engineering,2011,24(4):7-12.(in Chinese)
[28] 张辉,王晓波,张炜鑫,等.基体偏压对高功率脉冲磁控溅射CrN薄膜结构及阻氢性能的影响[J].真空科学与技术学报,2021,41(11):1046-1052.ZHANG Hui,WANG Xiaobo,ZHANG Weixin,et al.Effect of substrate bias on the structure and hydrogenbarrier properties of CrN films prepared by high powerpulsed magnetron sputtering[J].Journal of VacuumScience and Technology,2021,41(11):1046-1052.(inChinese)
[29] 张炜鑫.高功率磁控溅射CrN基薄膜的制备及其阻氢性能研究[D].哈尔滨:哈尔滨工业大学,2019.ZHANG Weixin.Preparation of CrN based thin films byhigh power magnetron sputtering and their hydrogenbarrier properties[D].Harbin:Harbin Institute ofTechnology,2019.(in Chinese)
[30] GUIMARAES M C R,NOSSA T D S,AVILA P R T,et al.On the effect of substrate oscillation on CrN coatingsdeposited by HiPIMS and dcMS[J].Surface and CoatingsTechnology,2018,340:112-120.
[31] 瞿全炎,邱万奇,曾德长,等.划痕法综合评定膜基结合力[J].真空科学与技术学报,2009,29(2):184-187.QU Quanyan,QIU Wanqi,ZENG Dechang,et al.Measurement of TIN film substrate interfacial adhesion byscratching[J].Chinese Journal of Vacuum Science andTechnology,2009,29(2):184-187.(in Chinese)
[32] 吴雁,肖礼军,王冰,等.TiAlSiN 多层梯度涂层力学及摩擦磨损性能试验研究[J].中国陶瓷,2020,56(9):36-42.WU Yan,XIAO Lijun,WANG Bing,et al.Experimentalstudy on mechanical and friction and wear properties ofTiAlSiN multilayer gradient coating[J].China Ceramics,2020,56(9):36-42.(in Chinese)
[33] ZHANG Xin,TIAN Xiubo,ZHAO Zhiwei,et al.Evaluation of the adhesion and failure mechanism of thehard CrN coatings on different substrates[J].Surface andCoatings Technology,2019,364:135-143

基金

黑龙江省自然科学基金联合引导项目(LH2019A014)和国家自然科学基金(11875119 和 12075071)资助项目
PDF(10271 KB)

14

Accesses

0

Citation

Detail

段落导航
相关文章

/