引用本文:王月梅,周惠娣,陈建敏,陈磊,冶银平.水性环氧粘结固体润滑涂层的摩擦学性能研究[J].中国表面工程,2010,(2):42~45
WANG Yue–mei, ZHOU Hui–di, CHEN Jian–min, CHEN Lei1, YE Yin–ping.Study on the Tribological Properties of the Waterborne Epoxy Bonded Solid Lubricating Coating[J].China Surface Engineering,2010,(2):42~45
【打印本页】   【HTML】   【下载PDF全文】   【查看/发表评论】  【EndNote】   【RefMan】   【BibTex】
←前一篇|后一篇→ 过刊浏览    高级检索
本文已被：浏览 3001次   下载 1894次 本文二维码信息
码上扫一扫！
分享到： 微信 更多
字体:加大+|默认|缩小-
水性环氧粘结固体润滑涂层的摩擦学性能研究
王月梅,周惠娣,陈建敏,陈磊,冶银平1,2
1.中国科学院兰州化学物理研究所 固体润滑国家重点实验室，兰州 730000;2.中国科学院 研究生院，北京 100049
摘要:
水性环氧粘结固体润滑剂，以水作为分散介质，具有价格低廉、无毒、不燃等优点，并且不含VOC，是一类有很好的发展前景的环保型润滑剂。制备了一种环保型的含MoS2、石墨和Sb2O3的性能优良的水性环氧粘结固体润滑剂，其具有优异的理化性能和摩擦学性能，尤其是在微动磨损的条件下，其摩擦学性能优于有机溶剂型粘结固体润滑涂层对比样品。环保的摩擦学性能优异的水性环氧粘结固体润滑剂的制备，为环保型润滑剂的发展提供了很好的依据。
关键词:  水性粘结  固体润滑涂层  摩擦学性能  二硫化钼
DOI：
分类号:
基金项目:国家自然科学基金委创新研究群体科学基金资助项目（50421502）；国家“973”计划资助项目（2007CB607601）
Study on the Tribological Properties of the Waterborne Epoxy Bonded Solid Lubricating Coating
WANG Yue–mei, ZHOU Hui–di, CHEN Jian–min, CHEN Lei1, YE Yin–ping1,2
1.State Key Laboratory of Solid Lubrication, Lanzhou Institute of Chemical Physics, Chinese Academy of Sciences, Lanzhou 730000;2. Graduate University of Chinese Academy of Sciences, Beijing 100049
Abstract:
In waterborne bonded solid lubricant system the solvent is water, which is green, cheap and no harm for human health. It is desirable in respect of environmental protecting because of its zero level of VOC. A novel and environmentally friendly waterborne epoxy bonded solid lubricating film was prepared, which included MoS2, graphite and Sb2O3, and the films had perfect tribological behaviour. It is worthy to point out that this novel waterborne bonded solid lubricant film characteristic of zero level of VOC and excellent tribological performance may provided evidence for environmental protecting lubricant.
Key words:  waterborne bonded  solid lubricating coatings  tribological properties  MoS2
手机扫一扫看